In the 2026 Malaysian regulatory landscape, Indoor Air Quality (IAQ) and Filtration Efficiency Validation have shifted from optional "wellness" features to mandatory statutory requirements. Under DOSH (JKKP) 2026 and the Industry Code of Practice on Indoor Air Quality (ICOP IAQ), building owners in KL and Selangor are legally obligated to prove that their AHU systems can maintain a sterile environment and mitigate bio-contaminants.
At EKG (Malaysia) SDN BHD, our validation protocols ensure your facility satisfies DOSH health audits while maintaining the energy efficiency targets set by the EECA 2024.
Current enforcement requires empirical proof that the AHU is delivering "Clean Air" as defined by the latest Malaysian standards.
Filtration Mandate: Per MS 1525:2024, AHUs in commercial spaces must utilize a minimum of MERV 13 (or F7 equivalent) filtration to capture fine particulate matter (PM2.5) and bio-aerosols.
CO2 Concentration Limit: Validation must prove the system maintains CO2 levels below 1,000 ppm. Exceeding this limit is a statutory violation of IAQ codes.
TVOC & Formaldehyde Audit: For newly renovated offices, validation includes testing for Total Volatile Organic Compounds (TVOCs) to ensure the AHU "flush-out" logic is effective.
We perform a three-stage audit to ensure your filtration system is a true barrier, not just a "dust catcher."
We measure the static pressure before and after the filter bank using digital manometers.
Low $\Delta P$: Indicates a "Bypass Leak" or a hole in the filter media.
High $\Delta P$: Indicates a "Loaded" filter that is spiking your Specific Fan Power (SFP) and wasting energy.
Utilizing NATA-traceable particle counters, we measure the concentration of PM2.5 and PM10 in the supply air stream vs. the return air. This verifies the actual Capture Efficiency of the installed MERV 13+ media.
A high-efficiency filter is useless if air leaks around the frame. We physically verify the gasket seals and frame rigidity to ensure 100% Seal Integrity, preventing "Unfiltered Bypass."
The success of IAQ validation depends on the mechanical health of the "wet" sections of the AHU.
Condensate Pan & Trap Audit: We verify the 1:100 statutory slope and the priming of the P-trap. Stagnant water is a primary source of mold and Legionella. A dry trap allows "Sewer Gas" or contaminants to be sucked into the building.
UV-C Intensity Verification: For units equipped with Germicidal UV-C lamps, we measure the $\mu W/cm^2$ output to ensure the dosage is sufficient to deactivate 99.9% of pathogens on the cooling coil surface.
Fresh Air Intake Positioning: We verify that the AHU's fresh air intake is not located near cooling towers or exhaust vents, preventing "Cross-Contamination" as per DOSH 2026 guidelines.
IAQ and filtration components must maintain integrity during a fire event per BOMBA (JBPM) 2026.
Filter Flammability: We verify that all filter media is UL 900 Class 1 or 2 (fire-retardant). Non-compliant filters can act as fuel and spread toxic smoke through the duct highway.
Smoke Purge Logic: Upon an Automatic Fire Signal AHU Shut-off, the IAQ sensors must yield control to the life-safety system. If the AHU is in "Smoke Purge" mode, the filtration system must be robust enough to handle the increased velocity without collapsing.
BOMBA Audit: JBPM officers witness the mechanical security of the filter banks during the annual Fire Certificate (FC) audit.
Technical Integrity: We are installation and T&C specialists, not fabricators. Our validation is an objective, empirical assessment of your indoor environment.
Audit-Ready Reports: We provide a comprehensive IAQ & Filtration Validation Report formatted for immediate use by your Registered Energy Manager (REM) and Safety Officer.
BEI Optimization: We balance IAQ needs with EECA 2024 energy caps. We ensure your filters are clean and efficient so your VFD-driven AHU doesn't waste power.
Is your AHU delivering sterile air or circulating bio-contaminants?
Contact EKG (Malaysia) SDN BHD today for a professional IAQ & Filtration Efficiency Validation.
更多 EKG M & E SDN BHD 相关资料
Malaysia
